-
PVC Pipe
This stuff is a miracle.
It is incredibly inexpensive and easy to work with. It is nontoxic and no special tools are needed. I lasts forever in the right conditions and the discus like it so much that they will lay their eggs on it.
It cuts easily with a common hacksaw blade. And if you cut it too short, it is so cheap to buy, you just cut another.
Pieces are bonded together using a simple inexpensive cement that leaves a joint that is stronger than the pipe itself. No special treatments are needed, just put the cement on and join the two parts. It dries quickly but not too quickly. And your fingers won't be part of the joint (like other cements that I won't mention). The wet cement is not good to breathe though.
Every hardware store sells the stuff and it comes with all sorts of valves, tees, 90s, caps, etc. and even solenoid controled valves. Adaptors are available to connect it to other systems too, threaded, etc.
It is real close to being the perfect material, I just wish it came in different colors (some people are never satisfied).
Did I leave anything out? Feel free to post tips, suggestions, or any benefits that I forgot to mention.
-
Re:PVC Pipe
I'll second that. In fact, my plumbing from the bulkheads to the drain for my breeding tanks isn't glued at all, just pressed together tightly. (garage w/cement floors .
On my 125 gal system, I have both the trickle filters plumbed with PVC and used aquarium silicone to bond the pieces. In all my years of doing this, no leaks, but I can twist it apart if I need to rearrange stuff.
Later, Steve
-
Re:PVC Pipe
Hey Steve,
Welcome to the board. I like that idea of using silicone as a reversible bonding agent.
You are right, the joints are usually tight without anything, though I don't have enough faith I guess, at least not for the living room.
-
Re:PVC Pipe
Aloha, I have seen the pvc in different colors. I asked the shop owner where he got them. He told me they were white at first. He sanded the pvc and then dyed them with food coloring. Blue for return water and red for exaust. I suppose it would work but I think to much hassle. If you like blue, meth/blu would probably do a good job.
Aloha Ike ;D
-
-
Re:PVC Pipe
I've found that once the fish figure out what the pvc is for they don't go back to anything else in the tank...Both my angels and discus spawn only on the pvc(unless i remove it, then the heater and filter are open season)
-
Registered Member
Re:PVC Pipe
Quick question ??? ??? ??? What do you all use to glue/bind the PVC pipes together??? ??? ??? ??? I need a binding agent that won't poison my discus:-X . The flows of the PVC pipes would be exiting and entering the tanks with H2O. Also where's a good place to pick this stuff at??? Home Depot??? If so a part number / manufacturer name would be great.
Also you all advised using aquarium silicone. Would that be just as good as a binding agent. Is this stuff readily available at the LFS???
Thanks all and sorry for all the questions. I just don't want to poison anybody. :-X
Thanks.
A- ;D
-
Re:PVC Pipe
Home Depot....either 100% silicone caulk,(100% silicone is aquarium safe, just get the clear stuff) or the pvc pipe glue...just make sure you give them at least 24 hrs to cure before using...If you can leave it for longer than that, that would be even better...
-
Re:PVC Pipe
Hi Allen,
The PVC cement actually bonds the pieces together and they will never come apart. The silicone holds the pieces together and can be pulled apart if you need to redesign. The silicone does not bond the PVC though and should be used with caution, especially if under pressure.
The PVC cement is available everywhere that they sell the PVC, it comes in various size cans usually.
To my knowledge, both give off toxic gases, toxic to you and the fish. Both should be used in ventilated areas. But both, once they are dry (24 to 48 hours) are very stable and probably inert. So like David said, let them cure for a day or two.
-
Registered Member
Re:PVC Pipe
Thanks guys. Damn looks like I have to return the silicone. I went to HOME DEPOT last night and the PVC cememnt was a lot cheaper than the silicone. Thanks again... ;D
A-
-
Registered Member
Re:PVC Pipe
Quick question - If I dripped a little of the PVC cement within the pipes and let it dry will it still be okay to use??? I'm using the PVC pipes to fill my tanks and with a little PVC Cement within the tube I'm wondering now whether or not it's safe or not. BTW I'm going to let the PVC pipe cure for 3 days just to be safe and use warm water to flush out the pipes before use. Please let me know as I don't want to poison anybody.
Thanks.
A-
-
Re:PVC Pipe
A, yes it will be fine....Randy
-
Re:PVC Pipe
While your at it make a few spanwing cones for your fish. This is from 1 1/4 PVC. Under the bottom piece while your at Home Depot/Lowes get a item where the PVC is located called a test plug. It fit's right in there and glue it to it with your Silicone Sealant. Once dry you can fill the tube half way with aquarium safe gravel by removing to top cap that I leave unglued. The gravel keep's it on the bottom of the tank and holds it steady.
-
Re:PVC Pipe
Hey George,
What a great idea, I've seen so many photos of eggs laid on PVC. It makes complete sense to intentionally put some PVC in their tank for them to use for their egg laying.
-
Re:PVC Pipe under gravel filtre
Hi there the board is very informative i was a discus beginner before i came to know about the board and now i have been able to cure hole in the head just by going through the board.
By the way PVC pipes are great i have made ugf from pvc pipes.
just cut them to the tank length and then u decide how many pipes u want to add to the width and join them with l bends and t type joints. And of course u have to drill holes on them at equi distant hole size depends on power head cpacity and type of gravel. works wonder for my 6foot by 1.5foot by 2foot tank and also for my 65 gallon discus tank.
for golden small sand you have to drill small holes.
i'll pose pictures if you allow and tell me how to post them.
sponge stripes can be inserted inside the tubes to increase the area available for benificial bacterias to grow.
niranjankirad@hotmail.com
Posting Permissions
- You may not post new threads
- You may not post replies
- You may not post attachments
- You may not edit your posts
-
Forum Rules